our products

D&Q Mining is a high-tech company integrating R&D, production and sales. It provides mature products and solutions such as crushers, sand making, milling equipment, mobile crushing stations, etc., for aggregate, mining and waste recycling.

full or partial fine aggregate replacement in concrete production pdf

REPLACEMENT OF FINE AGGREGATE WITH JAROFIX IN CONCRETE

consumption of sand as fine aggregate in concrete production is very high. The over ... concrete using copper slag for the partial replacement of fine aggregate and were found that 30% fine aggregate can be replaced effectively. Further, Patil and Patil[16] studied the workability, compressive strength, split tensile strength and permeability in M30 concrete replacing fine aggregate by copper ...

More

A Review of Partial Replacement of Fine Aggregate Coarse ...

partial replacement, fine aggregate, coarse aggregate. 1. INTRODUCTION Concrete is the second largest of widely used material; but there are environmental issues related with its use which are needed to be taken under considerations. Due to various factories and industries large volume of waste produced daily .The disposal of the waste generated from industries has become serious issue solid ...

More

(PDF) Partial Replacement of Copper Slag as Fine Aggregate ...

Figure 6 shows average compressive strengths of concrete test. VI. CONCLUSIONThe concrete was prepared for the M20 grade concrete with partial replacement of fine aggregate by copper slag with various percentages of (0%, 5%, 10%, 20%, 30%, 40%, 50%, and 60%). The specimens were casted for 7 days, 14 days and 28 days then tested. The results are presented above. The optimum value which

More

Replacement of fine aggregate with plastic in concrete

plastic as partial replacement of fine aggregate and tested for 7 28 days of compressive strength of concrete. ... 20% PET containers waste for fine total were delivered and contrasted against blend and no substitution or 0% substitution. The 3D square examples and shaft examples of 45 no of each were thrown, cured and tried for 7days and 28days quality. The pressure and flexural quality ...

More

(PDF) Utilization of Waste Glass as Partial Replacement of ...

The aim of this study is to improve the strength of concrete made by partial replacement of fine aggregate with waste Limestone. The fine aggregate was replaced by waste Limestone as (0-40%) with dosage ...

More

(PDF) REPLACEMENT OF FINE AGGREGATE WITH SAWDUST

In Group 3, wood waste aggregate has been used as a partial replacement of 10%, 15%, 20%, 25% and 30% by volume of coarse aggregate. The specimens were conditioned for 28-days at

More

(PDF) Effect of Partial Replacement of Coarse Aggregate by ...

The replacement of the 20%coconut shells as coarse aggregate and 10% fly ash as cement will decrease the marginal value of 0.205% in compression strength.Replacement by weight No. of cubes Cement (kg) Fine aggregate (kg) Coarse aggregate (kg) Water (liter) 10mm 20mm For 0% 6 9.35 17.67 10.78 10.78 4.20 For 10% 6 8.42 17.67 9.702 10.78 4.20 For 20% 6 8.42 17.67 8.624 10.78 4.20 For

More

Replacement of Coarse Aggregate by Demolished Brick Waste ...

It consists about 60 to 75 percent of total concrete production. Coarse aggregate comes from particles greater than 4.75 mm but commonly in a range between 9.5 mm to 37.5 mm. Therefore, the selection of coarse aggregate is vital for a good concrete mix such as it need to be clean, tough, and strong particles that free room absorbing chemicals. Furthermore, coarse aggregate also is significant ...

More

full or partial fine aggregate replacement in concrete ...

full or partial fine aggregate replacement in concrete production pdf Partial Replacement of Coarse Aggregate with 2018-1-24 investigations carried out to evaluate the effect of partial replacement of cement, fine aggregate and coarse aggregate by different parts of demolished wastes on strength and workability of concrete made.

More

full or partial fine aggregate replacement in concrete ...

Full Or Partial Fine Aggregate Replacement In Concrete Production Pdf. 2019-10-9characteristic studies on concrete by partial replacement of fine aggregate with waste granite powder molakani pavan kumar which has full-size compressive powergranite and sand for the production of concretehe high and growing value of these substances has greatly hindered the development of refuge and other

More

Effect of Partial and Total Replacement of Fine Aggregate ...

Effect of Partial and Total Replacement of Fine Aggregate by Mill Scale on the Properties of Concrete Arpit Chatter1, ... problems to technology choices that object the production of durable and environmentally friendly concrete are well related. The environmental impacts of the concrete industry by conservation of cement, aggregates, water or additives and admixtures can be reduced through ...

More

Partial Replacement of Coarse Aggregate with Demolished ...

replacement of cement, fine aggregate and coarse aggregate by different parts of demolished wastes on strength and workability of concrete made. For the study, design mix concrete of grade M25 (Referral concrete) was prepared using IS 10262-2009. Thereafter, the replacement of different constituents of concrete, one at a time was carried out by replacing these with the different sieved ...

More

Study on Strength of High Performance Concrete by Partial ...

refinery plants, has low cost and its application as a fine aggregate in concrete production reaps many environmental benefits such as waste recycling and solves disposal problems. Copper slag possesses mechanical and chemical characteristics that qualify the material to be used in concrete as a partial replacement as fine aggregate.

More

Egg Shell As A Fine Aggregate In Concrete For Sustainable ...

The usedegg shells were used as fine concrete aggregate. In the laboratory test, conventional fine aggregate was replaced at 100% replacement level. A total of 18 cubes were cast, cured and tested. The strength development of the concrete mixes containing egg shell aggregates was compared to that of conventional concrete with sand as fine aggregate. The result showed a reduction in compressive ...

More

Effects of Partial Replacement of Portland Cement and Fine ...

performance concrete production, the scientists are working on pozzolanic properties of materials. In the other case, waste Utilization would be economic and has noteworthy Result in source of global carbon dioxide (CO 2) emission, and environmental pollution control. This study finds the influences on behavior of concrete with the partial replacement of cement and fine aggregate at different ...

More

Experimental investigations on recycled coarse aggregate ...

Sabbrojjaman, Md, Mia, Ruman, Tafsirojjaman, Tafsirojjaman (2019) Experimental investigations on recycled coarse aggregate as a full or partial replacement of coarse aggregate in concrete production using high FM fine aggregates. In Alamgir, M., Rafiqul, I.M., Islam, S.M.T., Hasan, M.H., Datta, P. (Eds.) Proceedings of the WasteSafe 2019–6th International Conference on Integrated Solid ...

More

Partial Replacement of Fine Aggregate by Glass Powder in ...

The environmental and economic concern is that the biggest challenge the concrete trade is facing, the problems of environmental and economic concern are self-addressed by the utilization of waste Limestone as partial replacement of fine aggregates in concrete. Fine aggregates will be replaced by waste Limestone powder as 5%, 10%, 15%, 20% and 40% weight for M-20 mix. The concrete specimens will be ...

More

“Coconut Shell as Partial Replacement of Coarse Aggregate ...

“Coconut Shell as Partial Replacement of Coarse Aggregate in Concrete” - Free download as Powerpoint Presentation (.ppt / .pptx), PDF File (.pdf), Text File (.txt) or view presentation slides online. partial replacement of coarse aggregate

More

Partial Replacement of Cement in Concrete using Ceramic ...

Ceramic waste is hard and durable.Ceramic waste can be used as a partial replacement of cement or as a partial replacement of fine aggregate sand as a supplementary addition to achieve different properties of concrete [3]. Properties of Ceramic Powder:-Inorganic. Highly resistant to chemical and biological forces. Mainly composed of silica (69.4%) and alumina (18.2%), High strength. Good ...

More

Properties of environmental concrete that contains crushed ...

2020-08-18  Concrete production consumes a large amount of fine and coarse aggregates. Therefore, eliminating or reducing the consumption of aggregates in concrete can produce environment-friendly building materials. Considerable research has confirmed that the use of waste materials in concrete addresses the high utilisation of raw materials. Walnut is a common farming

More

Experimental investigation for partial replacement of fine ...

Experimental investigation for partial replacement of fine aggregates in concrete with sandstone 0.15 mm sieve (Prashanth et al. 2010). A study on Jharia coal mining fields in India revealed that 98% of the particles were retained on 75 µm and higher sieve sizes while washing sandstone (Rai et al. 2011). A study conducted in Raniganj coal ...

More

Partial Replacement of Coarse Aggregate with Demolished ...

replacement of cement, fine aggregate and coarse aggregate by different parts of demolished wastes on strength and workability of concrete made. For the study, design mix concrete of grade M25 (Referral concrete) was prepared using IS 10262-2009. Thereafter, the replacement of different constituents of concrete, one at a time was carried out by replacing these with the different sieved ...

More

Investigation on Fine Aggregate by Broken Tiles in Concrete

Abstract: This examination manages the effect on the concrete by the partial replacement of fine aggregate by ceramic aggregate. Studies were done on a concrete, with various replacement. The impacts of various replacements 0, 10, 20, 3040 percent of the waste ceramic tile by weight of concrete with M-30 review. At last, it was reasoned that ...

More

Egg Shell As A Fine Aggregate In Concrete For Sustainable ...

The usedegg shells were used as fine concrete aggregate. In the laboratory test, conventional fine aggregate was replaced at 100% replacement level. A total of 18 cubes were cast, cured and tested. The strength development of the concrete mixes containing egg shell aggregates was compared to that of conventional concrete with sand as fine aggregate. The result showed a reduction in compressive ...

More

A PERFORMANCE STUDY ON PARTIAL REPLACEMENT OF

production of concrete. Waste plastic was used as a partial replacement for sand by 0%, 5%, 10%, 15%, 20%, 25%, 30%, 35%, 40%, 45%, 50% and 55% with concrete mixtures. These tests include performing slump, compressive strength, and split tensile strength. For Compressive strength tests, concrete cubes of size 150mm x150mm x 150mm were used. Split tensile strength tests were

More

Coconut Shell as Partial Replacement for Coarse Aggregate ...

184 within the range of structural lightweight concrete. Coconut shell aggregate concrete satisfies the requirements of ASTM C 330. Reference [1] Adeyemi AY.,(1998) ,“ An investigation into the suitability of coconut shells as aggregates in concrete production” ,Journal of

More

Waste Materials in Concrete Technology: Sustainability and ...

replacement of natural coarse and fine aggregates with recycled-concrete aggregates can be compensated by incorporation of fly ash and water- reducing chemical admixtures into the new fresh concrete mixture. This paper is a review of the research work done in the last few years in order to promote recycling into concrete for common use in building construction [Naik Moriconi 2005], with

More

Performance of Concrete By Using Animal Bone Powder And ...

fine aggregate in concrete as potential building material in making concrete. 2. An exploratory study on the suitability on animal bone as paratial or full replacement for normal fine aggregate . 3. Bone powder as partial replacement for normal fine aggregate and adding fly ash as 10% of cement replacement in concrete works has been carried out in order to reduce the construction cost. 4. To ...

More

“Coconut Shell as Partial Replacement of Coarse Aggregate ...

“Coconut Shell as Partial Replacement of Coarse Aggregate in Concrete” - Free download as Powerpoint Presentation (.ppt / .pptx), PDF File (.pdf), Text File (.txt) or view presentation slides online. partial replacement of coarse aggregate

More

What are the Materials for Replacement of Sand in Concrete ...

F.M of Ideal fine aggregate for concrete applications are in range of 2.6 to 2.9. Fine sand (lower F.M Value ) reduces the sand requirement % in the total aggregate proportion. On the other hand, coarser sand will require higher sand % in the total aggregate proportion to give a cohesive concrete mix consuming least cement. Any material which are basically chemically inert and having particle ...

More

Study on Strength of High Performance Concrete by Partial ...

refinery plants, has low cost and its application as a fine aggregate in concrete production reaps many environmental benefits such as waste recycling and solves disposal problems. Copper slag possesses mechanical and chemical characteristics that qualify the material to be used in concrete as a partial replacement as fine aggregate.

More

Egg Shell As A Fine Aggregate In Concrete For Sustainable ...

The usedegg shells were used as fine concrete aggregate. In the laboratory test, conventional fine aggregate was replaced at 100% replacement level. A total of 18 cubes were cast, cured and tested. The strength development of the concrete mixes containing egg shell aggregates was compared to that of conventional concrete with sand as fine aggregate. The result showed a reduction in compressive ...

More

A PERFORMANCE STUDY ON PARTIAL REPLACEMENT OF

production of concrete. Waste plastic was used as a partial replacement for sand by 0%, 5%, 10%, 15%, 20%, 25%, 30%, 35%, 40%, 45%, 50% and 55% with concrete mixtures. These tests include performing slump, compressive strength, and split tensile strength. For Compressive strength tests, concrete cubes of size 150mm x150mm x 150mm were used. Split tensile strength tests were

More

Coconut Shell as Partial Replacement for Coarse Aggregate ...

184 within the range of structural lightweight concrete. Coconut shell aggregate concrete satisfies the requirements of ASTM C 330. Reference [1] Adeyemi AY.,(1998) ,“ An investigation into the suitability of coconut shells as aggregates in concrete production” ,Journal of

More

Performance of Concrete By Using Animal Bone Powder And ...

fine aggregate in concrete as potential building material in making concrete. 2. An exploratory study on the suitability on animal bone as paratial or full replacement for normal fine aggregate . 3. Bone powder as partial replacement for normal fine aggregate and adding fly ash as 10% of cement replacement in concrete works has been carried out in order to reduce the construction cost. 4. To ...

More

Using Shredded Tires as an Aggregate in Concrete

2012-09-12  with shredded tires as a fine and coarse aggregates. Seventy two concrete (100x100x100) mm cubes were prepared for this study. The replacement of aggregates with shredded tires was partially or completely in the concrete cubes according to the mix designs required in terms of weight and strength. The specimens were cured in water for up to ninety days before testing. Test

More

Feasibility assessment for partial replacement of fine ...

2016-11-01  The aggregates are key components of the concrete matrix and comprise about 70% of the total volume of concrete. Fine aggregates make up for approximately a quarter of the total volume of the concrete matrix. However, such a large scale consumption of concrete has strained the natural sources of raw material procurement over the past few decades. There has been a marked decrease

More

Replacement of Sand with Bauxite Mining Waste in Concrete ...

The aim of this study is to examine the possibility of using bauxite mining waste as a fine aggregate replacement for concrete production. The quantities of sand replaced with bauxite mining waste used are 0, 25, 50, 75 and 100%. Cube, cylinder and beam specimens were molded and cured for 7, 14, 21 and 28 days, and tested for density, compressive strength, tensile splitting strength and ...

More

Performance of Waste Coconut Shell as Partial Replacement ...

Concrete production demands its constituents like aggregates, cement, water and mixtures. Sources of conven- tional aggregates occupy the major part of the concrete. The large scale production of concrete in construction activities using conventional coarse aggregate such as granite immode-rately reduces the natural stone deposits and affecting the en-vironment hence causing ecology imbalance ...

More

Figure 3 from Partial Replacement of Coarse Aggregate with ...

Corpus ID: 215821068. Partial Replacement of Coarse Aggregate with Waste Glass in Concrete Production @inproceedings{RachaelO2019PartialRO, title={Partial Replacement of Coarse Aggregate with Waste Glass in Concrete Production}, author={Olomo Rachael.O}, year={2019} }

More